И н ф о р м а ц и о н н ы й н а у ч н о - т е х н и ч е с к и й ж у р н а л
Уважаемые коллеги!
До кризиса 2008 г. размер мирового
№ 6 (161), 2012 г. Издается с апреля 1998 г.
РЕДАКЦИЯ
Ген. директор издательства
Главный редактор
Зам. главного редактора
Н.Л. ПоПов
Зам. гл. редактора по маркетингу и развитию
Выпускающий редактор
Дизайн и верстка
Компьютерный набор
РЕДАКЦИОННЫЙ СОВЕТ
БАЖеНов Юрий Михайлович – зав. кафедрой «Технология
вяжущих веществ и бетонов» МГСУ, акад. РААСН, д-р техн. наук, проф.
БАрИНовА Лариса Степановна – зам. председателя
Комитета по предпринимательству в сфере строительства и ЖКХ
Торгово-промышленной палаты, канд. хим. наук
ГУСев Борис владимирович – президент РИА, акад. РИА, МИА,
чл.-корр. РАН, заслуж. деятель науки РФ, лауреат Гос. премии СССР,
лауреат Гос. премии РФ, д-р техн. наук, проф.
ДМИТрИев виктор викторович – зам. директора Патриаршего
архитектурно-реставрационного центра, д-р геол.-минерал. наук, проф.
ЛАПИДУС Азарий Абрамович – президент холдинговой компании
«СУИхолдинг», заслуж. строитель РФ, д-р техн. наук, проф.
ЛоБов олег Иванович – председатель Российского общества
инженеров строительства, д-р техн. наук
ТеЛИчеНко валерий Иванович – ректор МГСУ, академик РААСН,
заслуж. деятель науки РФ, д-р техн. наук, проф.
ПОПЕЧИТЕЛЬСКИЙ СОВЕТ
· Московский государственный строительный университет
· Российская академия архитектуры и строительных наук
· Российская инженерная академия
· Российское общество инженеров строительства
· Департамент градостроительной политики города Москвы
· Департамент строительства города Москвы
АДРЕС РЕДАКЦИИ
129343, Россия, Москва, пр-д Нансена, д. 1, офис 34, «Композит XXI век»
Т./ф.: (495) 231-44-55 (многокан.).
Internet: http://www.stroymat21.ru
E-mail: info@stroymat21.ru; reklama@stroymat21.ru
УЧРЕДИТЕЛЬ И ИЗДАТЕЛЬ ЖУРНАЛА
© ООО «Композит XXI век» при поддержке ЗАО УИСЦ «Композит».
При научно-технической поддержке МГСУ.
Рег. номер ПИ № 77-18526 от 7 октября 2004 г.
Набрано и сверстано в ООО «Композит XXI век».
Подписано в печать
25.05.2012 г.
Отпечатано в типографии ООО «Юнион Принт».
603022, г. Нижний Новгород, ул. Окский съезд, д. 2
Общий тираж 15000 экз.
Редакция не несет ответственности за содержание рекламных материалов
и достоверность опубликованных в авторских статьях сведений.
Перепечатка материалов без разрешения редакции запрещена.
П А Р Т Н Е Р Ы Н О М Е Р А :
д-р техн. наук, проф. Л.Н. ПоПов
А.И. Мокрецов
Ю.Н. НАУМов
А.в. ДИДевИч
Б.С. кУрТИШ
Л.о. СПИрИДоНовА
рынка ЛКМ составлял $100 млрд, или
25 млн т, а объем российского рынка
– 5% от общемирового потребления,
т.е. около 1,1-1,2 млн т. В 2008-2009 гг.
суммарно отечественное производство
ЛКМ упало на 18,5%.
Однако уже в 2010 г. произошло его
быстрое восстановление, и прирост за
год составил 24,6%. Прошлый и нынешний
годы показывают устойчивость этой
тенденции. Можно прогнозировать прирост
15-20%, что превышает общемировые
темпы. Это свидетельство динамики
и потенциала отечественного рынка. Но надо понимать, что рынок ЛКМ
в значительной мере развивается на базе зарубежных технологий и что
иностранным компаниям выгоднее производить продукцию внутри
страны, чем поставлять из-за рубежа.
По разным оценкам, общее число предприятий, фирм и ИП, выпускающих
ЛКМ на российском рынке, колеблется от 600 до 1200.
Структуру производителей кратко можно представить следующим
образом: 1-я группа – до 10 крупнейших компаний, на которую приходится
до 40-42% объема производства ЛКМ. Эта группа стабильна. 2-й
эшелон – 20-25 компаний с объемом производства 4-5 тыс. т в год. Эти
2 группы дают свыше 65% общего объема выпуска ЛКМ. Прослеживается
четкая тенденция увеличения их доли до 70% за счет ухода неэффективных,
со старыми технологиями средних и мелких компаний. Вторая
причина – ужесточение требований по охране окружающей среды.
Третья – экономическая целесообразность.
Тенденции современного рынка показывают: технологии развиваются
в сторону сокращения использования растворителей. Приоритет – производству
и применению материалов с высоким сухим остатком (более
60%) и практических не содержащих растворителей (менее 5%), композиций
на водной основе и порошковых материалов. Тренд этого года рост
производства на 25% связывается с появлением молодых амбициозных
компаний, ожиданием восстановления активного спроса и увеличением
объемов строительства. К числу таковых можно отнести и российскую
компанию из Екатеринбурга Asttika, применившую европейский подход
к организации производства: мощное предприятие (30 тыс. т. ЛКМ в
год) на малой площади. Завод будет производить первую в мире линейку
«интеллектуальных» ЛКМ, основанных на инновационной intellastтехнологии.
Iintellast – компоненты, позволяющие распознавать тип и
состояние любой поверхности и обеспечивающие максимальную защиту
на молекулярном уровне. Эти компоненты целенаправленно воздействуют
на источник проблемы: плесень, ржавчину, трещины или неровности,
ликвидируют его и препятствуют возобновлению.
На отечественный рынок продукция поступает под брендом Asttika
Professional paint systems. Материалы Asttika составят серьезную конкуренцию
продукции крупнейших производителей в 27 регионах РФ.
Кроме того, компания планирует выйти на рынки стран СНГ, Европы
и Ближнего Востока.
Евгений АСТАПОВ, генеральный директор компании Asttika
Стр.3
Ежемесячный
информационный
научно-технический
журнал
s u m m a r y
Masters of brick
This article underlines that ceramic bricks despite the
variety of building materials in the segment of housing
construction confidently hold the leading position.
Moreover its popularity continues to grow due to the
expense of dynamic development of new directions of
brick production – output of large format ceramic blocks
used for load-bearing structures (p. 8).
MATERIALS
Kolnogorova A.V. The jubilee. 25 years later...
The start of dry method production has become a
significant event that opened a new page in the 98 years
history of «Nev’yanskiy cementnik» plant. On December
30, 1987 the State Commission adopted cement plant
operation activities with capacity of 1,150 mio tons of cement
per year with full technological cycle based on the
latest for that time energy-saving technology (p. 10).
The highly efficient thermal roof insulation
This article presents the main options for construction
of thermal isolated roofing for inversion, lightweight
and industrial flat and roof slopes as well as the decision
of insulation during the overhaul of the roof with the
use of modern high-efficiency material «Extrol» (p. 14).
С О Д Е Р Ж А Н И Е
Новости стройкомплекса ................................................................... 4
Кирпичных дел мастера ..................................................................... 8
МАТЕРИАЛЫ
Колногорова А.В. Юбилей. 25 лет спустя... ........................................ 10
Высокоэффективная теплоизоляция кровли .................................... 14
Газобетон сберегает тепло ................................................................. 16
Сальников М.М. ООО «Фабрика универсальных покрытий» –
нанотехнологии в действии! Новое напольное покрытие
всего за 2 часа ........................................................................... 18
ОБОРУДОВАНИЕ
Устьянов В.Б., Иващенко В.В. Новые методы и приборы для
ускоренного исследования керамического сырья ......................... 21
Тарчигина Н.Ф., Фомилева Т.В., Галкина Ю.М. Исследование
влияния химического состава глины на качество готовой
керамической продукции ............................................................... 25
ТЕХНОЛОГИИ
Балакина А.Е., Дуничкин И.В., Шульга Т.В. Развитие программы
«Одноэтажная Россия» энергоэффективным и экологическим
строительством ............................................................................... 30
Родин С.Г., Четверик Н.П. Комитет инновационных
технологий в строительстве НОСТРОЙ выходит
на новые рубежи ...................................................................... 32
Ананьев А.А. Повышение надежности и безопасности наружных
стен зданий и сооружений, облицованных кирпичом .................. 34
Поздеев С.В., Некора О.В., Поздеев А.В. Исследование адекватности
математических моделей свойств материалов для расчета
огнестойкости железобетонных плит ............................................. 36
Белов В.В., Смирнов М.А., Образцов И.В. Теоретические
основы методики оптимизации гранулометрического
состава композиций для изготовления безобжиговых
строительных конгломератов ......................................................... 41
Сапожников А.И. Учет пространственной работы сил в зданиях –
путь к обеспечению их сейсмостойкости ....................................... 44
ИНФОРМАЦИЯ
Копылов И.А. До встречи на MosBuild-2013 ...................................... 48
Все флаги в гости к нам, на берега Босфора ..................................... 50
Патенты на изобретения .................................................................... 52
Aerated concrete saves warmth
Heat and energy saving implies in the first system solution,
the effectiveness of which largely depends on the
physico-chemical properties of the used building material.
To the assortment of the trade mark Bonolit added
an innovative product Bonolit D300 – aerated concrete
block with a low coefficient of heat conductivity was
added (p. 16).
Salnikov M.M. Motto of the «Factory of the universal
coverings» company: «Nanotechnologies is in
action!»
Only 2 hours are enough for new floor covering. One
need to mix up two banks with a special composition
and strike it on virtually any surface. After 2 hours you
will receive an innovative, high-strength and a designed
covering of a floor (p. 18).
EQUIPMENT
Ustyanov V.B., Ivashchenko V.V. New methods
and instruments for faster analysis of ceramic raw
material
The authors have developed new methods and instruments
that speed up by a factor of ten, the determination
of characteristics and technical applications of ceramic
raw material. With the help of these methods and
instruments we are able to study the processes of drying,
glazing, water absorption, freezing, as a dynamic system,
significantly raising both the accuracy and the benefit
of the data obtained (p. 21).
Tarchigina N.F., Fomileva T.V., Galkina Yu.M. The
studies of the influence of the clay chemical composition
upon the quality of the ceramics products
The authors consider the influence of different additives
upon both the quality and the properties of
the bricks; they describe various physical and chemical
methods including the X-ray phase analysis and the
deviation-graph analysis (p. 25).
TECHNOLOGIES
Balakina A.E., Dunichkin I.V., Shulga T.V. Development
of «Single-storey Russia» program of energyefficient
and ecological construction
This article notes that increase of rates of housing
construction focusing only on the multi-storey housing
will not succeed. Implementation of «Single-storey Russia»
project in the framework of the national status with
the support of the state and by the private initiative in
the field can to some extent help to reduce the acuteness
of the issue (p. 30).
Стр.4
s u m m a r y
Rodin S.G., Chetverik N.P. The Committee of innovative
technologies in the construction NOSTROY
goes to new frontiers
Article analyzes the activities of the Committee
NOSTROY. Purpose of this article – to draw attention
to the construction community to assess the effectiveness
of innovative technologies in construction
based on the newly developed recommendations
(p. 32).
Ananiyev A.A. Safety and reliability increasing
outside walls buildings and constructions covered
by brick
Increasing requirements for the thermal insulation
of walls led to the use of new designs of external walls
of buildings that had a positive experience in some
European countries. However, several years after the
commissioning of these buildings, brick cladding layers
of external walls began to crumble. The reasons for the
onset of an emergency condition are in the specifics and
peculiarities of the building complex and diverse climatic
zones of Russia (p. 34).
Pozdeev S.V., Nekora O.V., Pozdeev A.V. The study
of the adequacy of the mathematical models of the
properties of materials for the calculation of fireresistance
of reinforced concrete slabs.
Results of the study of the adequacy of the complexes
of mathematical models of the properties of
concrete and rebar are considered in this article. They are
recommended by various normative documents and by
the authors of scientific works as well (p. 36).
Belov V.V., Smirnov M.A., Obraztsov I.V. Theoretical
bases of the technique of optimization of granulometric
structure of compositions for manufacturing
of not roast structure construction conglomerates
This article deals with preconditions of optimal
designing of building blends compositions in order
to obtain concrete on the cement binding, based
on polydisperse structures formation regularity. The
choice of methods of modeling of granular bulk systems
packing and calculation of optimal grading of
raw blends with the most dense grains packing, providing
optimal parameters for blends compaction is
given (p. 41)
Sapozhnikov A.I. Calculation of spatial forces’ work
in buildings – the way to supply of their seismic stability
Earthquakes
cause shifting and rotation of the basic
ground. As a result, buildings are deformed in the spatial
way. Calculation of mutual work of a basis, a foundation
and a building needs can be found in solution of the
huge system of equations so some errors connected with
mistakes in calculations and due to the human reason are
possible. The approximate but simple and visual methods
of buildings’ calculation are used for the control of calculations’
exactness (p.44)
INFORMATION
Kopylov I.A. Welcome to MosBuild-2013.
MosBuild is the largest European Annual International
Construction and Interior Exhibition in Russia with 18year-old
history organized by the ITE team. Nearly 2,3
thousand companies-participants from 45 countries and
more than 100 thousand specialists of the construction
industry from all over the world visited the show this year
(p. 48).
All flags on a visit to us, on the shores of the
Bosphorus
From 2 to 6 may 2012 in Istanbul hosted the annual
International Construction Exhibition TurkeyBuild
which was visited by publishing’s house «Kompozit
XXI vek» representative Alenka Krajacic from AK
marketing&consult, exclusive agent for European countries.
Get some impressions from this report (p. 50).
C O N T E N T S
News of construction industry ............................................................. 4
Masters of brick .................................................................................. 8
MATERIALS
Kolnogorova A.V. The jubilee. 25 years later... ....................................... 10
The highly efficient thermal roof insulation .......................................... 14
Aerated concrete saves warmth ........................................................... 16
Salnikov M.M. Motto of the «Factory of the universal coverings»
company: «Nanotechnologies is in action!» ....................................... 18
EQUIPMENT
Ustyanov V.B., Ivashchenko V.V. New methods and instruments
for faster analysis of ceramic raw material ........................................ 21
Tarchigina N.F., Fomileva T.V., Galkina Yu.M. The studies
of the influence of the clay chemical composition upon
the quality of the ceramics products ................................................. 25
TECHNOLOGIES
Balakina A.E., Dunichkin I.V., Shulga T.V. Development
of «Single-storey Russia» program of energy-efficient
and ecological construction .............................................................. 30
Rodin S.G., Chetverik N.P. The Committee of innovative technologies
in the construction NOSTROY goes to new frontiers .......................... 32
Ananiyev A.A. Safety and reliability increasing outside walls
buildings and constructions covered by brick .................................... 34
Pozdeev S.V., Nekora O.V., Pozdeev A.V. The study of the adequacy
of the mathematical models of the properties of materials
for the calculation of fire-resistance of reinforced concrete slabs ........ 36
Belov V.V., Smirnov M.A., Obraztsov I.V. Theoretical bases
of the technique of optimization of granulometric structure
of compositions for manufacturing of not roast structure
construction conglomerates ............................................................. 41
Sapozhnikov A.I. Calculation of spatial forces’ work in buildings –
the way to supply of their seismic stability ........................................ 44
INFORMATION
Kopylov I.A. Welcome to MosBuild-2013 ............................................. 48
All flags on a visit to us, on the shores of the Bosphorus ...................... 50
Patents for inventions .......................................................................... 52
Informative
science-and-engineering
journal
Стр.5